2008-2014 Scion xD A/C System O-Ring and Gasket Kit Guide
Losing your cool? Here’s what you need to know about the A/C seals in your 2008-2014 Scion xD.
- This kit is not a standalone repair; it's a required set of seals for any A/C component replacement.
- A/C system repair is not DIY-friendly; it requires expensive, specialized equipment and professional knowledge.
- Always replace the receiver/drier when the A/C system is opened to ensure the longevity of the repair.
- A quality aftermarket kit from a brand like Four Seasons is a cost-effective and reliable choice for this vehicle.
Is Your Scion xD A/C Blowing Warm Air?
If the air conditioning in your 2008-2014 Scion xD isn't as cold as it used to be, the most common cause is a refrigerant leak. While the leak could be from a damaged hose or a failing component, it often happens at the connection points. Over time, the original rubber o-rings and gaskets can become hard, brittle, and shrink, allowing refrigerant to escape. You might also notice an oily residue on A/C line fittings, which is the refrigerant oil that circulates with the gas. An A/C System O-Ring and Gasket Kit is not a repair in itself, but a required part of any A/C repair job, such as replacing the compressor or condenser.
Check This Common Scion xD Issue First
Before you assume a major A/C problem, check the passenger side floor for dampness. A well-documented issue on the 2008-2012 Scion xD is a clogged HVAC evaporator drain, which can cause water to back up and leak into the cabin. A Technical Service Bulletin (TSB) was issued for this problem. This is separate from the sealed refrigerant system but is a common A/C-related complaint.
Choosing the Right Aftermarket O-Ring Kit
When your mechanic opens the A/C system to perform a repair, they must replace all the seals they disconnect. While you can buy individual seals from a Toyota/Scion dealer, a complete aftermarket kit is often more convenient and cost-effective. The quality of these seals is critical; a failed o-ring means the entire expensive A/C service will have to be repeated.
For your Scion xD, two common aftermarket brands are available:
- Four Seasons: Generally considered a reliable and trusted aftermarket brand for A/C components. Many professional shops use Four Seasons parts. While not always identical to OEM, their quality is usually sufficient for a lasting repair.
- Global Parts (GPD): Often viewed as a budget-friendly option. While functional, the general consensus in repair forums suggests keeping expectations in line with the price. They can be a viable choice if cost is the primary concern.
OEM vs. Aftermarket Quality
The original equipment (OEM) seals are the benchmark for fit and material quality. However, for a vehicle of this age, a quality aftermarket kit from a known brand like Four Seasons is a perfectly acceptable and common choice for repairs. The most important factor is that the seals are new and made from the correct refrigerant-compatible material (HNBR). An old seal, even if it's OEM, will fail.
Expected Costs for A/C Seal Replacement
Remember, you are not just paying for the seals. The cost is part of a larger A/C repair. The labor involves recovering old refrigerant, replacing the main failed part and all related seals, pulling a vacuum to remove moisture, and recharging with the correct amount of new refrigerant.
| Item | Estimated Cost |
|---|---|
| New Aftermarket O-Ring & Gasket Kit | $26 - $29 |
| Shop Labor (A/C Evacuate & Recharge Service) | $150 - $250 |
| Total (Part of a larger repair) | Varies widely based on total repair |
Note: Labor costs do not include the time to replace the primary failed component (e.g., compressor, condenser). These are typical costs for the A/C service portion of the job.
Frequently Asked Questions
Can I replace the A/C o-rings myself?
No, this is not a recommended DIY job. Replacing the seals requires opening the pressurized A/C system. It is illegal to release refrigerant into the atmosphere, and specialized equipment is needed to recover the old refrigerant, pull a vacuum, and recharge the system correctly. This job should be left to a qualified mechanic.
Do I need to replace anything else at the same time?
Yes. Any time the A/C system is opened to the atmosphere, the receiver/drier (or accumulator) must be replaced. This component contains a desiccant that absorbs moisture from the refrigerant. Once exposed to air, it becomes saturated and useless. Failing to replace it can lead to corrosion and failure of your new parts.
Are there any recalls on the Scion xD A/C system?
No, there are no safety recalls specifically for the A/C system on the 2008-2014 Scion xD.
What is a TSB and are there any for my A/C?
A Technical Service Bulletin (TSB) is a notice from the manufacturer to dealers about common problems and recommended repairs. For the Scion xD, there is a general TSB about diagnosing the A/C system after a component fails and a specific one about a clogged drain causing water leaks into the cabin.
Technical Specifications
OEM Part Numbers: 90069-08007 (Example of one of many individual o-rings)
Kit contains multiple HNBR (Hydrogenated Nitrile Butadiene Rubber) o-rings and gaskets compatible with R134a refrigerant. Must be replaced any time the system is opened.
We Have This Part in Stock
The information in this article is provided for general reference and educational purposes only. Vehicle specifications, procedures, and part compatibility can vary by production date, trim level, and region. Always consult your vehicle's factory service manual and verify part numbers before purchasing or performing repairs. Safety-critical components such as airbags, seat belts, and braking systems should be installed by a qualified professional.
- Scion xD: